Open Access Open Access  Restricted Access Subscription Access

Ornithipter Type Flapping Wings for Autonomous Micro Air Vehicles

Sutthiphong Srigrarom, Woei-Leong Chan

Abstract


In this paper, an ornithopter prototype that mimics the flapping motion of bird flight is developed, and the lift and thrust generation characteristics of different wing designs are evaluated. This project focused on the spar arrangement and material used for the wings that could achieves improved performance. Various lift and thrust measurement techniques are explored and evaluated. Various wings of insects and birds were evaluated to understand how these natural flyers with flapping wings are able to produce sufficient lift to fly. The differences in the flapping aerodynamics were also detailed. Experiments on different wing designs and materials were conducted and a paramount wing was built for test flight. The final prototype has a length of 46.5 cm, wing span of 88 cm, and weighs 161 g. A mechanism which produced flapping motion was fabricated and designed to create flapping flight. The flapping flight was produced by using a single motor and a flexible and light wing structure. A force balance made of load cell was then designed to measure the thrust and lift force of the ornithopter. Three sets of wings varying flexibility were fabricated, therefore lift and thrust measurements were acquired from each different sets of wings. The lift will be measured in then cycles computing the average lift and frequency in three different speeds or frequencies (slow, medium and fast). The thrust measurement was measure likewise but in two cycles only. Several observations were made regarding the behaviour of flexible flapping wings that should aid in the design of future flexible flapping wing vehicles. The wings angle or phase characteristic were analyzed too and studied. The final ornithopter prototype weighs only 160 g, has a wing span of 88.5 cm, and produce a maximum thrust and lift of about 0.719 N and 0.264 N respectively.

Full Text:

PDF

References


W. Shyy, Y. Lian, J. Tang, D. Vileru, and H. Liu, Aerodynamics of Low

Reynolds Number Flyers, 1 ed. New York: Cambridge University Press,

(2008)

M.A. Groen, PIV and force measurements on the flapping-wing MAV

DelFly II, Delft University of Technology M.Sc. thesis, (2010)

C.P Ellington., C. Van den Berg, A.P. Willmott, A.L.R. Thomas,

Leading-Edge Vortices in Insect Flight, Nature, Vol. 384, pp. 626-630,

(1996)

K. D. Jones and M. F. Platzer, Design and development considerations

for biologically inspired flapping-wing micro air vehicles, Experiments

in Fluids, vol. 46, pp. 799-810, (2009)

F. V. Breugel, W. Regan, and H. Lipson, From Insects to Machines.

IEEE Robotics & Automation Magazine, pp. 68-74 (2008)

C.P., Ellington, The aerodynamics of hovering insect flight III

Kinematics, Phil. Trans. R. Soc. Lond. B, vol. 305 (1984)

M. H. Dickinson, The effects of wing rotation on unsteady aerodynamic

performance at low reynolds numbers, The Journal of Experimental

Biology 192, 179-206, (1994)

M. H., Dickinson, F. -O. Lehmann, and S. P. ,Sane, Wing rotation and

the aerodynamic basis of insect flight, Science 284: 1954-1960 (1999)

P. S. Sane, The aerodynamics of insect flight, The Journal of

Experimental Biology, vol. 206, pp. 4191 - 4208, (2003)

R.Sayaman S. N. Fry and M. H. Dickinson, Unsteady mechanisms of

force generation in aquatic and aerial locomotion., Amer. Zool., 36, 537-

, (1996)

A. Azuma, "The Biokinetics of Flying and Swimming," Springer,

Tokyo, (1992)

R. F. Chapman, The Insects: Structures and Function, 4 ed. New York:

Combridge University Press (1998)

D. E. Alexander, Nature's Flyers: Birds, Insects and the Biomechanics of Flight: The Johns Hopkins University Press, (2004)

C. Ellington, "The Novel Aerodynamics of Insect Flight: Applications to

Micro Air Vechicles," The Journal of Experimental Biology, pp. 3439-

, 15/09/1999 (1999)

F-O. Lehmann; S. Pick, The aerodynamic benefit of wing - wing

interaction depends on stroke trajectory in flapping insect wings, The

Journal of Experimental Biology 210, 1362-1377, (2007)

A. Roland Ennos, The kinematics and aerodynamics of the free flight of some diptera, The Journal of Experimental Biology 142, 49-85, (1989)

C. Van Den Berg, C.P. Ellington, The three-dimensional leading-edge

vortex of a hovering model hawkmoth, Philosophical Transactions:

Biological Sciences 352, 329-340, (1997)

D. R. Warrick; B.W. Tobalske; D.R. Powers., Aerodynamics of the

hovering hummingbird, Nature 435 1094-1097, (2005)

K. P. Dial, B. W. Tobalske, W. L. Peacock, Kinematics of flap-bounding

flight in the zebra finch over a wide range of speeds, The Journal of

Experimental Biology 202, 1725-1739, (1999).

A.D. Young, M.A., A review of some stalling research, pp 6, (1951)

Y.S. Hong, A. Altman, An Experimental Study on Lift Force Generation

Resulting from Spanwise Flow in Flapping Wings, 44th AIAA

Aerospace Sciences Meeting and Exhibit, Reno, Nevada, (2006)

Blake, C.H., More data on the wing flapping rates of birds, The Condor, Vol. 50, No. 4, p. 148 (1948)




DOI: http://dx.doi.org/10.21535%2FProICIUS.2012.v8.771

Refbacks

  • There are currently no refbacks.